My tuning journey

Dr.Phatpants
8/23/26, 11:04 AM

8/23/26 My current ride is an 07 Spirit vt750c2. I picked her up last summer. Right now she has between 17k and 18k miles. I absolutely love riding this bike. Decided Im going to customize her to my liking. As of today I haven't riden her in almost 4 weeks and to be honest, its starting to bother me. Anyway, I have installed open exhaust and v stack. Couple other shiny cosmetics that dont apply to this.

Took the carb off, took it apart and cleaned it, used the performance kit from tjbc. Started with the 50 pilot jet and 148 main. Double shim on the needle. Reinstall carb and she'll only idle with the enrichment value pulled out. Running lean, cool.

Today I have time to work on it. Switch out the 50 pilot for the 55. Still will only idle with enrichment valve pulled out. So now im going to take the carb off again, clean everything again, and check the float height this time. When I get paid Thursday I'll probably buy some new spark plugs just to have them.

Anyway, thats where im at right now. If anyone has any suggestions im open to them. Ill post on here again and hopefully she'll be idling properly.

**UPDATE ** 8/29/26

I finally got the bitch running today and I am over joyed! Pulled the carb, took it apart, and gave all the pieces a good soak for about 30 minutes in a big ass can of carb cleaner. Then took my time with a brass brush, spray can carb cleaner, and canned air i cleaned everything up and sprayed all the holes and crevices out. Reassembled everything. Started the 50 pilot and 148 main. Float height is JUST below 18.5 mm. Used my stock gas line. (Originally I had used new line I cut longer because the stock is a bitch to get on.)

Forgot about the choke and she fired right up and idled. After fucking with the air/fuel screw and idle screw for a couple minutes I got idle is sit around 1200. (Bought a cheap tach that wraps around the plug wire.) Little bit of black smoke out the exhaust and possible afterfire. Partial throttle seemed good to go. Was getting dark so im done for the day. Tomorrow going back at her. Might be a little rich at idle.

**note** vstack, exhaust, and performance kit are all tjbc. I did Originally replace the carb boot. I did remove and install exhaust gaskets**

I'd rather be mediocre at fixing my motorcycle than great at pickleball

0 likes 0 likes

3
Posts

22
Views
Dr.Phatpants
8/30/26, 10:33 AM

8/30/26

Turned the air/fuel screw IN to about 2 1/4 turns out and again to about 2 turns out. She's idling fine, quarter throttle sounds fine. At idle there is still a little black smoke coming out the exhaust. Doesn't seem to be any smoke when the throttle is applied. Any advice or words of encouragement are appreciated. Im going to take her out on the road and see how she does

I'd rather be mediocre at fixing my motorcycle than great at pickleball

0 likes 0 likes
Dr.Phatpants
8/30/26, 12:07 PM

8/30/26

Turned the air/fuel in to about 1 3/4, she starts and idles great. Apply throttle still good to go. If there's any black smoke coming out the exhaust its very hard to see. Turn bike off. Remove the tachometer, attach the speedo to the tank, attach the seat. Go to start up, won't start. Rock the bike there's fuel in the tank, feels low. Switch to reserve, try again, nothing. Use the choke, still nothing.

So now im stumped. I dont have time to today but at some point this week imma check the plugs. Is there anything else anyone can think of?

I'd rather be mediocre at fixing my motorcycle than great at pickleball

0 likes 0 likes

Please login to reply to this topic!